Really a perfect combination of power and price. Secure the watercraft on a stand or trailer. Turn off the water and stop the engine. Check the impeller seal for cracks or damage. Place a shop towel around the oil filter cartridge to avoid spilling the engine oil.
Measure the spark plug between the center and side electrodes with a wire-type feeler gauge. If idle speed increases, check the throttle lever free play and the throttle cable connection. The following items require some mechanical knowledge. Impeller clearance is critical for proper performance. Warm up the engine for a few minutes according to the flushing procedure. Screw the spark plug in the cylinder head by hand to prevent cross-threading.
Warm up the engine with the watercraft in the water and check the idle speed. Check the jet stator inner wall for scratches. Perform the same lubrication procedure for joint hole. Yamaha Waverunner Super Jet Service Manual Wave Runner Pdf can be very useful guide, and Yamaha Waverunner Super Jet Service Manual Wave Runner Pdf play an important role in your products. Install the removed parts in the reverse order of removal.
Does the starter motor turn? Relay Coil Power Input Line Inspection Check the power input line of the starter relay switch. Does the starter relay switch function properly? Clean around the spark plug bases with compressed air before removing the plugs, and be sure that no debris is allowed to enter the combustion chamber and remove the spark plugs. Check the fuel feed and return hoses for deterioration, damage or leakage and make sure the hoses are secured with the hose clamp properly. Add the recommended engine oil into the oil tank through the filler hole until oil is on the dipstick. Tighten the spark plug to the specified torque. Remove the joint hoses from the clip s and disconnect the maintenance joint. I bought my wave runner brand new in June 2006.
Spray the lubricant into joint hole for 3 seconds. Starter Relay Switch Inspection Check the function of the starter relay switch. Other, much more expensive brands and models really dont offer that much more power and speed to justify the added expense. Reinstall the drain pipe cap and tighten it. Repeat the step 2 — 5 again.
Five minutes of idling is sufficient. It's red, and most people don't see it as being 8 years old. Check the ground line of the starter relay switch. Install the joint hoses into the clip s properly. With the engine idling, turn the handlebar all the way to the right and left to ensure that the idle speed does not change. Consult an authorized Yamaha dealer. To date I have 135 hours.
Check the insulator for cracks or damage, and the electrodes for wear, fouling or discoloration. I do my regular maintance once a year and I keep my battery maintainer onthem so that the battery is always charged and ready I love them and they run great. Release the four retainers and remove the airbox cover. Starter Relay Switch Operation Inspection 4. After draining the oil completely, install the drain pipe cap and pour the recommended oil into the oil tank through the filler hole. The problem is that once you have gotten your nifty new product, the Yamaha Waverunner Xl700 Service Manual Wave Runner Pdf gets a brief glance, maybe a once over, but it often tends to get discarded or lost with the original packaging.
To view more specifications, visit our. Pump out the engine oil with a commercially available Fluid Evacuator from the oil filler hole and drain pipe, to drain the oil tank and oil pan. To lubricate and rustproof the inside of the throttle body, proceed as follows after confirming that the engine is stopped and cool. Is the ground line normal? Compression too low, hard starting or poor performance at low speed. The problem is that once you have gotten your nifty new product, the Yamaha Waverunner Super Jet Service Manual Wave Runner Pdf gets a brief glance, maybe a once over, but it often tends to get discarded or lost with the original packaging.
Disconnect the ignition coil connectors. It is fuel efficient, can go for 2 or 3 hours on 5 gallons of gas. I've had it for 4 years never a had a major mechanical issue with i. Check for any deterioration or damage to the throttle cable. Be sure the rubber seal in the cover is in good condition and install the airbox cover. Check the throttle lever for smooth operation.